The gasoline Club Car Carryall 294 utility vehicle uses a low-pressure impulse/diaphragm pump. If it cranks but will not start or starves under load, check fuel at the pump inlet, the pulse/impulse hose and pump outlet flow before replacing the pump.
Carryall 294 • Symptoms + testing
Carryall 294 fuel pump quick diagnosis
No-start first
Confirm fuel reaches the pump inlet, then inspect the pulse/impulse hose before blaming the pump.
Starts then dies
Tank vent, filter restriction and suction-side air leaks often mimic pump failure on this carbureted setup.
Under load
A weak diaphragm or leaking pulse hose may keep up at idle but starve the engine when demand rises.
After replacement
If the new pump still will not feed fuel, recheck inlet, outlet and pulse-port routing.
Carryall 294 bad fuel pump symptoms
Cranks but will not start
Verify fuel reaches the pump inlet and that the pump receives a usable engine pulse. If both are present but no fuel exits, suspect the pump.
Runs then dies
Check the tank vent, filter and suction hose for restriction or air leaks that slowly starve the carburetor.
Sputters under load
A weak diaphragm, leaking pulse line or restricted filter may keep up at idle but fail during acceleration.
New pump, still no fuel
Recheck inlet, outlet and pulse-port routing; a correctly sized new pump will not work with swapped hoses.
Fuel in pulse line
Inspect the diaphragm and pulse plumbing; the pulse line is for engine pressure pulses, not normal fuel flow.
Intermittent delivery
Look for loose clamps, soft hose that collapses under suction, debris at the pickup and a blocked tank vent.
How to test the Club Car Carryall 294 fuel pump
Carryall 294 fuel-system specifics
Pump/system: Impulse/diaphragm pump.
Engine/system: Legacy Club Car gasoline.
Pressure guidance: Low-pressure carbureted.
Model-specific note
Applicable older gasoline versions use the legacy carbureted/impulse-pump arrangement. Exact FE350 or other engine application and hose routing should be verified by serial prefix/year.
Club Car Carryall 294 fuel pump FAQ
What type of fuel pump does the Club Car Carryall 294 use?
The gasoline Club Car Carryall 294 utility vehicle uses impulse/diaphragm pump. On this setup, the pump depends on engine pulse/impulse action rather than EFI pressure.
What are the most common Club Car Carryall 294 fuel-pump symptoms?
Typical Carryall 294 symptoms are hard starting, starts-then-dies behavior, weak acceleration, starvation under load and little or no fuel leaving the pump outlet.
How do I test the Club Car Carryall 294 fuel pump?
Check three things in order: fuel reaching the pump inlet, a healthy pulse/impulse hose from the engine, and fuel coming out of the pump outlet while cranking. If inlet fuel and pulse are good but outlet flow is weak, the pump becomes the likely fault.
Can the pulse line cause Club Car Carryall 294 fuel-pump problems?
Yes. A split, loose, blocked or collapsing pulse/impulse hose can stop a healthy diaphragm pump on the Carryall 294 from drawing fuel properly.
Why does the Club Car Carryall 294 run at idle but starve under load?
On the Carryall 294, that usually points to a weak diaphragm pump, a leaking pulse hose, a restricted filter, a blocked tank vent or a suction-side air leak that only shows up when fuel demand rises.
What should I check before buying a new Club Car Carryall 294 pump?
Check the filter, tank vent, inlet hose condition and exact hose routing first. Also confirm whether your specific year uses the same low-pressure carbureted setup described in this page. Applicable older gasoline versions use the legacy carbureted/impulse-pump arrangement. Exact FE350 or other engine application and hose routing should be verified by serial prefix/year.
Fuel-system design, wiring, pressure specifications and replacement parts can vary by model year, engine and configuration. Before testing or ordering parts, confirm the details in the official owner, operator, parts or service manual for your exact Club Car Carryall 294 and serial range. For current documentation, visit the official manufacturer website.